Welcome To Our Mining Equipment Production Base!
Comparative Analysis of Different Waste Materials that can ...

D. Partial Replacement of Sand with Sawdust in Concrete Production Objective This study investigates the use of sawdust as partial replacement for fine aggregates in concrete production. Sawdust was used to replace fine aggregates from 0% to 50% in steps of 10%. Concrete cubes measuring 150 x 150 x 150mm

Read More
AN EXPERIMENTAL INVESTIGATION ON THE EFFECT OF …

EFFECT OF REPLACEMENT OF FINE AND COARSE AGGREGATE BY SAWDUST IN SOLID CONCRETE BLOCKS FOR DIFFERENT MIX PROPORTIONS 1Owais Ahmad Lone, 2Anaab Saleem, 3Isha Chandra 1M.Tech Student, 2B.Tech Student, 3Assistant Professor 1Civil Engineering, 1NIU, Greater Noida, India Abstract:

Read More
Compressive Strength Evaluation of Concrete A ... - IJESRT

0% replacement of cement and fine aggregate with cow dung and saw dust was 18.89N/mm2 after curing for 28 days, while the compressive strength of the concrete at 2% replacement of cement and fine aggregate with cow dung and saw dust was 17.55N/mm2 after curing for 28 days as shown on table 1.2 and 1.3.

Read More
SOLIGNUM TREATED SAWDUST AS FINE AGGREGATE IN CONCRETE …

The cost of construction has been on the increase which has become a concern to both individuals and government of especially developing countries, and that is why this study is aimed at using available cheap materials (sawdust) in concrete production. Concrete mix ratio of 1:2:4 was used and replaced with fine aggregate at 5%, 10%, 15% and 20% with soligum …

Read More
Investigations on sawdust and Palm Kernel Shells as ...

This study involved experimental tests, workability and compressive strength tests, on concrete specimen using saw dust as partial replacement for fine aggregate and palm kernel shell as partial replacement for coarse aggregate in concrete production for rigid pavements. The coarse aggregate sizes used here ranges from 5mm to 12.5mm.

Read More
Production of Light Weight Concrete Using Sawdust As Raw ...

Production Of Light Weight Concrete using Sawdust As. Partial Replacement In Coarse Aggregate. An undergraduate project Presented BY ONAH COLLINS OGECHUKWU (20151020603) NWACHUKWU MICHAEL CHUKWUMA (20151022123) UGWUEGBULAM HARRY (20151016053) Department Of Material and Metallurgical Engineering Federal …

Read More
The Use of Sawdust and Palm kernel Shell as Substitute for ...

6. Like all light weight aggregate, concrete made from shell may be useful for thermal insulation, in the making of pre-stressed concrete (Anthony, 2000). Sawdust as an aggregate in concrete: Sawdust can be used as alternative substitute for fine aggregate in concrete production. Sawdust should be washed and cleaned

Read More
ISSN: 2456-9992 Performance Of Compressed Lightweight ...

concrete are cleanliness, grading; hardness and the shape. Both organic natural aggregate sawdust and grounded fish scales and inorganic natural i.e. sand are being blended for production of lightweight masonry blocks. 2.1.1 River sand Fine Aggregate The fine aggregate used in river sand obtained from river Nzoia.

Read More
Aggregates for Concrete

More performance tests are also used to test aggregates in concrete. A typical consensus specification for fine and coarse aggregate for concrete is ASTM C 33. Synthetic aggregates may be either byproducts of an industrial process, in the case of blast-furnace slag, or products of processes developed to manufacture aggregates with special

Read More
Investigating the acceptable quantity of fine aggregate to ...

The study was an experimental study on hollow concrete blocks in a partial replacement of fine aggregate with sawdust in different proportion. The amount and kind of cement was constant, but the quantity of sawdust, aggregate and water was varied.

Read More
EFFECT OF FLY ASH AND QUARRY DUST AS A PARTIAL …

to study the effect of partial replacement of fine aggregates by quarry dust and cement by fly ash on cement concrete. 1.2 NEED FOR INVESTIGATION Quarry Dust These residues are generally less than 1% aggregate production in the normal concrete. The introduction of quarry dust for mixing is limited due to its high fineness.

Read More
Mahmud Abubakar - Academia.edu

This study investigated the use of sawdust as partial replacement for fine aggregates in concrete production. Sawdust was used to replace fine aggregates from 0% to 50% in steps of 10%. Concrete cubes measuring 150 x 150 x 150mm were cast and their compressive strengths evaluated at 7, 14, 21 and 28 days.

Read More
[PDF] Effect of Sawdust as Fine Aggregate in Concrete ...

This experimental study aimed to develop an acceptable concrete mixture with sawdust particles as substitute to fine aggregate that can be used for building construction particularly in residential class concrete slab and analyze the effect of sawdust concrete mixture in terms of adhesion of aggregates, thermal insulation, workability and surface quality.

Read More
Table of content for a project work on sawdust in partial ...

Table of content for a project work on sawdust in partial replacement of fine aggregate in concrete production Products. As a leading global manufacturer of crushing, grinding and mining equipments, we offer advanced, reasonable solutions for any size-reduction requirements including, Table of content for a project work on sawdust in partial replacement of fine …

Read More
Partial Replacement Of Fine Aggregate With Dust

PARTIAL REPLACEMENT OF CEMENT AND FINE investigation, stone dust, a waste material obtained from crusher plants is used as partial replacement of cement and fine aggregate M25 grade of concrete was taken for this investigation with a final mix proportion of 1:179:292 at w/c ratio of 050 The replacement levels of cement and fine aggregate with stone dust were 5%, …

Read More
Suitability of Crushed Cow Bone as Partial Replacement of ...

are being used annually for the production of ordinary concrete consisting of 1.5 billion tons cement, 1 billion tons of water, and 9 billion tons of aggregates. Aggregates consist of fine aggregates and coarse aggregates. Generally aggregate less than 4.75 mm is classified as fine aggregate. The popular and most

Read More
Concrete using agro-waste as fine aggregate for ...

Dec 01, 2016· The Agricultural wastes used as fine aggregate in concrete are sugarcane bagasse ash, groundnut shell, oyster shell, sawdust, giant reed ash, rice husk ash, cork and tobacco waste. The major differences of these agro-wastes are the place from where they collected and the processes to convert into a fine aggregate.

Read More
Structural Behaviour of Crushed Fine Ceramic Tiles as ...

concrete increased with increase in granite powder and it has been observed that the compressive strength is maximum at 30% of coarse aggregate replacement.[4] used crushed ceramic waste and pumice stone as a partial substitute for fine aggregates in the production of mortar and concrete,

Read More
Alternative fine aggregates in production of sustainable ...

Sep 20, 2020· It is found that crushed brick mortar (CB) fine aggregate have more dust and fine particles lesser than 75 μm than crushed concrete aggregates (Martinez et al., 2013; Aggarwal and Siddique, 2014). The fineness modulus of the CB is around 3.60–3.91 whereas for crushed concrete is around 3.10–3.65 ( Martinez et al., 2013 ; Katz and Kulisch ...

Read More
Investigation on Mechanical Properties of Lightweight ...

Jul 08, 2019· Investigation on Mechanical Properties of Lightweight Concrete Partially Replacing Sawdust to Fine Aggregate. ... Uses of saw dust as admixture in production of low cost and light weight. 2012 American Journal of Scientific and Industrial Research, 3(6): 458-463. ... You, W., Zhang, C.Y., Li, H.H., Hu, J. (2013). The implementation of waste saw ...

Read More
Effectiveness of wood waste sawdust to produce medium- to ...

The density of sawdust concrete mixtures decreases with the sawdust replacement that could be helpful in producing lightweight concrete. • The presence of sawdust as a fine aggregate replacement had shown reduced compressive and flexural strength.

Read More
Evaluation of the performance of eco-friendly lightweight ...

as an alternative lightweight fine aggregate and cementitious material respectively in eco-friendly lightweight interlocking concrete paving units (ICPU) using a mix ratio of 1:2:4. The lightweight sawdust and laterite were studied due to their abun-dant availability as industrial waste and cheap local construction material. Eco-

Read More
(PDF) Effect of Fine Aggregate Types on the Compressive ...

Also concrete made from groundnut better the physical properties of the fine aggregate, the shell and sawdust yielded low compressive strengths as higher the workability of the concrete and specific gravity follows; crushed groundnut shell (2.9N/, 4.3N/, of the fine aggregate, and also the higher the compressive 5.1N/ and 5.8N/ ) and sawdust ...

Read More
Investigation of Properties of Concrete Using Sawdust as ...

The percentage replacements of fine aggregates by sawdust were varied from 0%, 25%, 50%, 75% and .This was done to determine the optimum percentage that would give the most favorable result. However, dry mix method was used for …

Read More
Study of Sawdust Concrete Properties as Construction …

materials such as cement, basalt and sand for the production of concrete. The River sand which is most commonly used fine aggregate in the production of concrete, posses the problem of acute shortage in many areas, whose continued use has started posing serious problems with respect to its availability, cost and environmental impact.

Read More
Suitability of Sawdust as Partial Replacement for Fine ...

This experimental study aimed to develop an acceptable concrete mixture with sawdust particles as a substitute to fine aggregate that can be used for building construction particularly in the ...

Read More
Title Page Thesis.docx - Immaculate Conception Academy ...

Title Page Thesis.docx - Immaculate Conception Academy South Campus COMPARATIVE STUDY OF FINE AND COARSE SAWDUST AS AN …

Read More
OFFSHORE SAND AS A FINE AGGREGATE FOR CONCRETE …

89 construction materials (clay, bricks, a aggregate) or construction works (foundation fill, dikes 90 etc.). Much as the sea sand used in concrete is controversial, it is still an effective measure 91 to relieve the shortage of sand [5]. Studies show that (DMS) can be successfully used as a 92 fine aggregate for concrete production [2, 6]. 93

Read More
REPLACEMENT OF FINE AGGREGATE WITH SAWDUST

the fine aggregate. It is also used to analyze the effect of sawdust concrete in terms of workability, adhesion of aggregates and etc. After preparing the concrete block, the difference in weight between the original concrete and the sawdust concrete block is also tested. The sawdust is mixed in definite proportions with the concrete.

Read More
Partial Replacement Of Sand With Sawdust In Concrete

Elizabeth Joseph/, "Partial replacement of fine aggregates with sawdust for concrete", International Journal for technological research in engineering Vol.3, (2016). [3] Daniel Yaw Osei, Emmanuel Nana Jackson/, "Compressive strength of concrete using sawdust as aggregate", International Journal of scientific & ...

Read More
SOLIGNUM TREATED SAWDUST AS FINE AGGREGATE IN …

Key words: Solignum Treated Sawdust, Fine Aggregate, Concrete Production Cite this Article: Gana. Abu James and Yusuf Timi Daniel, Solignum Treated Sawdust as Fine Aggregate in Concrete Production, International Journal of Civil Engineering and Technology (IJCIET) 9(12), 2018, pp. 252–260.

Read More
Partial Replacement of Cement with Corn Cob Ash and Saw ...

Dust Ash and Fine Aggregates with Steel Slag in Concrete V. Rushendramani [1], G. Ganesh Naidu [2] M. Tech student [1], Assistant Professor [2] Department of Civil Engineering PACE Institute of technology India ABSTRACT Corn cob ash-Saw dust ash and Steel slag are the most used among such materials to replace cement and fine aggregate

Read More
Alternative fine aggregates in production of sustainable ...

The economic, sustainability and social benefits increases utilizing into concrete. Literatures have shown the possibility of AFA in construction as replacement to natural fine aggregate however, a comprehensive study on different AFA in concrete is required …

Read More